In order to investigate the stability of Hydroxyapatite (HA) coated material, the plasma-sprayed coatings of HA were divided into four groups: 1. Keeping in water vapour at 125 degrees C, with a pressure of 0.15 MPa for 6 hr; 2. Heating at 650 degrees C in air for half an hr; 3. Keeping in water vapour at 490 degrees C, with a pressure of 0.01 MPa for 2 hr; and 4. The control. The XRD, FTIR analysis and the dissolution test were carried out. The results showed: 1. The degree of crystalization in XRD analysis was 3. gt; 1. gt; 2. gt; 4.; 2. The ampitude of OH- peak in FTIR analysis was 3. gt; 1. gt; 2. gt; 4. and 3. The dissolution rate in tris-HCl buffer was 3. lt; 1. lt; 2. lt; 4. The conclusions were 1. The treating with water vapour could decrease the transformation temperature which was needed to convert the amorphous phase into cystalline phase; 2. Water vapour treatment could accelerate the transformation of Z-TCP, TCPM into crystalline HA; 3. Water vapour treatment could promote the structural integrity of plasma--sprayed coated of and HA and 4. Water vapour treatment could lower the dissolution rate of HA coated in Tris-HCl buffer.
Objective To evaluate the biocompatibility and safety of a novel orthopedics materials-graded zirconia(ZrO2)hydroxyapatite(HA) composite biomaterials. Methods First, ultrafine powers of ZrO2 and HA powder were prepared by chemical precipitation method, then graded ZrO2-HA composite was synthesized by dry-laying and sintering method. After the physiological saline and culture medium extracts of the composite were prepared, four experiments were conducted as follows:① The mouse acute toxic test consists of 2 groups(n=10). The extracts were intravenously injected to mice in the first group, and physiological saline to mice in the second group. The dose was 50 g/kg. Their toxicity manifestation, morality and the change of weight were recorded.② The standard curve of proliferation and metabolism of L929 cells was established. ③ The cytotoxinic test consists of 3 groups: materials group (extracts of the materials), positive control group (culture fluid with 0.64% phenol), and negative control group (RPMI-1640 culture fluid). Each of three was cultured with cell suspension, and then the morphology of the cells was observed, the relative proliferation rate (RGR) was calculated, and the toxicity was classified. ④ In vitrohemolytic test was divided into 3 groups: extracts, sterile distilled water (positive control) and 0.9% physiological saline. In each of three, 0.2 ml anticoagulant diluted fresh rabbit blood was added. The percentage of hemolysis was tested. ⑤ The muscle and implantation test were divided into 4 groups(n=3). The composite biomaterials were implanted into pygal muscleson either side and lateral condyles of femurs. After surgery, the rats of four groups were sacrificed at 12 and 24 weeks respectively.Tissue slice and scanning electronic microscopy were performed. Results General acute toxic test: no mouse died within 3 weeks; no toxicity symptom or adverse effects were shown within 3 days. The weight of materials group increased by 3.57±0.49 g, and the control group by 3.62±0.61 g, showing no statistically significant difference（Ρgt;0.05）.The standard curve of L929 cell perliferation and metabolism showed that their existed a positive correlation between the number of L929 cells and the perliferation. ③ Cytotoxinic test: cytosomes in the positive control group diminished and appeared round, there were pyknotic nucleus, the attached cells agglomerated; the toxicity was level Ⅳ. The morphology of cells in materials groupand negative control group was normal, and the number of them increased; the toxicity was level Ⅰand level 0, respectively. The MTT color experiments showed that positive control group was significantly lower than materials group and negative control group, showing statistically significant difference (Plt;0.01); there was no statistically significant difference between materials group and negative group.④ Hemolytic test: in vitrohemolytic rate of negative control group was0, of positive control group was 100%, and of materials group was 1.66%, which accords with the standard that hemolytic rate should be lower than 5% specified in ISO. ⑤ Implant test:No apparent rejection reaction took place after the composite was implanted; the composite bonded with the bones of the receptors firmly, which had good bonedinduced effect. Conclusion Graded ZrO2-HA composite bioceramic has good biocompatibility and is suitable for orthopedic biomaterials.
Objective To investigate and compare the osteogenic potential of three kinds of calcium phosphate ceramic as carriers for recombinant human bone morphogenetic protein-2(rhBMP-2) in vivo.Methods BCPceramics (HA,TCP,HA/TCP) impregnated with rhBMP-2 (experimental groups) and without rhBMP-2(control groups) were implanted into 6 muscles pockets on the dorsum of 3month-old Wistar rabbits. The rabbits were sacrificed 2, 4 and 8 weeks after implantation and bone induction was estimated by alkaline phosphatase(ALP) activity measurement. The implants were also examined histologically and histomorphometrically by HE staining and computerized graphical analysis. Results The ALPactivity of implants withrhBMP-2 was higher than that of control groups(P＜0.05), but there was no difference between 2 and 4 weeks in experimental groups. In all experimental groups,theimplants exhibited that new bone formation increased with the lapse of time. The amount of new bone formation is more in -HA/rhBMP-2 group than in the other two group in the 2nd and 4th weeks, but there was no difference between them (P＞0.05).In the 8th week, the amount of bone formation was most in HA/TCP with -rhBMP-2, and was more than that in the 2nd and 4th weeks. Whereas in control groups, there was only fibrous connective tissue. Conclusion HA/TCP- is a good carriers of rhBMP-2 and can be used as bone substitutes clinically.
Repair of bone defect by compound of bone morphogenic protein (BMP) and its prior bone matrix gelatin (BMG) was compared with repair by BMP with hydroxyapatite(HA). The results showed that the BMP/BMG group was found fibrous callus in the bone defect in 4th week. In 8th week a large quantity of osseos trabecula was found. In 12th week the BMP was absorbed completely and was replaced by newly formed bone. In 16th week the recanalization appeared in the bone cavity. While in the BMP/HA group, although the fibrous callus was appeared in the 4th and 8th weeks, the HA was not absorbed. In the 12th and 16th weeks the change was similar to that in the 8th week and no recanalization of bone marrow cavity. It was suggested the BMP/BMG compound might be an ideal material to repair the bone defect.
OBJECTIVE To confirm membrane-guided tissue regeneration in the healing course of segmental bone defects and study the mechanism. METHODS Segmental, 1 cm osteoperiosteal defects were produced in both radii of 12 rabbits. One side was covered with hydroxyapatite/polylactic acid(HA/PLA) membrane encapsulated as a tube. The contralateral side served as an untreated control. Healing courses were detected by radiographic and histologic examinations. RESULTS All control sides showed nonunion, whereas there were consistent healing pattern in test sides. CONCLUSION Membrane technique can promote bone regeneration.
Objective To study an optimal ratio of small intestinal submucosa (SIS) and (hydroxyapatite-tricalcium phosphate,HA-TCP,SIS/HA-TCP) compositions according to the effect of SIS/HA-TCP compositions with different ratios on repairing rabbit femoral condyle defect. Methods Thirty-six rabbits were made into bone defect models of 6 mm in diameter and 10 mm in depth in both sides of femoral condyles. Three different ratios of SIS/HA-TCP compositions (w/w: 1, 0.5, 0.25) were implanted into rabbit femoral condyle defect. After 2, 4, 8 and 12 weeks of operation, the repair effect wasobserved grossly. The histological evaluations were performed by histological scoring system and computer imaging analysis system. Results The amount of new bone formation in SIS/HA-TCP(0.5) group was more than that in SIS/HA-TCP(1) and SIS/HA-TCP(0.25) groups. Histological observation: In SIS/HA-TCP(1) group, few new bone formation was seen and bone defect was repaired in the 12th week. In SIS/HA-TCP(0.5) group, immature woven bone was found in the defect in the 2nd week; more immature woven bone appeared and formed trabeculae in the 4th week; the regenerated bone was vigorously growing into the interspaces of the implanted materials in the 8th week; the implanted materials was basically replaced by bony structure and the lamellar bone appeared in the 12thweek. The results of SIS/HA-TCP (0.25) group were similar to that of SIS/HA-TCP(0.5) group. The histological scoring was higher in SIS/HA-TCP(0.5) and SIS／HA-TCP(0.25) groups than that in SIS/HA-TCP(1) group (Plt;0.05) in the 2nd, 4th, 8th, and 12th weeks. The scoring was higher in SIS/HA-TCP(0.5) roup than that in SIS/HA-TCP(0.25) group in the 2nd and 12th weeks(P＜0.05). In new bone formation and the degradation of HA-TCP, SIS/HA-TCP(0.5) and SIS／HA-TCPC(0.25) groups were superior to SIS/HA-TCP(1) group(Plt;0.05), SIS/HA-TCP(0.5) group was superior to SIS/HA-TCP(0.25) group (Plt;0.05). Conclusion SIS/HA-TCP(0.5) has better effects of repairing bone defect and it can be used as a reference ratio in constructing bone scaffolds.
OBJECTIVE: To evaluate the clinical effect of drilling procedure following the hydroxyapatite orbital implantation. METHODS: From February 1996 to April 2000, 146 consecutive patients who received hydroxyapatite orbital implant were drilled and inserted a motility peg 6 to 16 months after hydroxyapatite implantation. Among them, there were 97 males and 49 females, aged from 18 to 60 years old, of the 146 motility pegs, 36 were sleeved pegs and 110 were nonsleeved. Goldman visual field analyzer was applied to measure the degree of artificial eye’s movement before and after drilling. RESULTS: Followed up for 1 to 40 months, no secondary infection occurred. The mobility of the prosthesis increased from (18.7 +/- 3.8) degrees preoperatively to (42.3 +/- 3.7) degrees postoperatively. CONCLUSION: The delayed drilling procedure and motility peg insertion improve the range of movement and the sensitivity of the artificial eye with a low rate of complications.
Natural nonorganic bone(NNB) was obtained after the fresh bone of pig was heated to 100℃. The NNB was white and in a shape as its original bone.The tensile strength of the compact bone was 200kg/cm3 and that of the cancellous bone was 25kg/cm3. The ratio of calcium to phosphorus was 10∶6. The main componentwas hydroxyapatite. The material was composed of trabeculae and intertrabecular spaces. Three experiments were performed. Experiment 1: 18 pieces of NNB in a size of 0.5×0.5×0.5cm3 were implanted intothe back muscle of 18 rabbits. At 4, 8 and 12 weeks after the operation, 6 specimens were obtained seperately and were stained by HE, and then examined under microscope. The result showed that the mesenchymal cells had no regeneration and differentiation, and the NNB and the surrounding tissues had no evidence of formation of new bone or chondrosynthesis. This NNB did not produce rejection reaction between tissues but the new blood vessels could easily grow into the space of the NNB. The fibrils had intimate contact with NNB. Experiment 2: The NNB and hydroxyapatite(HA) were mixed to make a cylindroid body with 2mm in diameter and 4mm in length and was implanted in the bilateral tibias of 40 rabbits, respectively. The roentgenography, fluroscent microscopic examination and histological observation were carried out at 2, 3, 4 and 8 weeks after the implantation. Experiment 3: In 50 rabbits, a defect of 2.5cm was made on both radius, and in one sideNNB was implanted and the other side was served as the control. Another 50 rabbitsHA was implanted in the defect in one side and the other side was served as the control. The results showed that in the NNB group at the 16th week, the bone united in 16 of the 30 cases, while in the HA group, in the 30 cases,only 2 had the bone united, while those of the controls no union had occurred.It was suggested that NNB had more formation of new bone than HA did.
Objective To investigate aesthetic outcomes and postoperative complications of hydroxyapatite particulate artificial bone for repairing sunken deformation of frontal bone following removal of dermoid cyst. Methods From February 2000 to May 2005, hydroxyapatite particulate artificial bone was used to repair the sunken deformation of frontal bone in 13 cases (9 males and 4 females), and the age of the patients was from 17 to 41 years. The dermoid cysts were all found during infant period, and the length and width of the cysts ranged from 6 cm×4 cm to 10 cm×8 cm. Anincision along the hairedge or tumor margin was made to excise the dermoid cyst in the forehead. After complete removal of dermoid cyst, the sunken frontal bone was examined and repaired with hydroxyapatite particulate artificial bone. The clinical checkup and Xray examination were utilized to determine aesthetic outcomes and postoperative complications at 1 week, 1 month and 6 months after operation. Results The primary wound healing was obtained in allpatients postoperatively, and no complications such as hematoma, infection, recurrence of dermoidcysts or displacement of hydroxyapatite particulate artificial bone were observed. With a followup from 1 to 20 months, all sunken deformations were completely repaired with satisfactorily aesthetic outcomes. Through clinical checkup and X-ray examination, the implants were found to integrate with the frontal bones without any gaps and displacement. Conclusion It is a simple and viable method torepair sunken deformation of frontal bone with hydroxyapatite particulate artificial bone.
The primary results of five patients in whomthe block hydroxyapatite artificial bone (BHAB)used in maxillofacial plastic repair were reported. All incisions healed up with no evidence ofinfection. None of the implants was rejected norhad resorption changes. Satisfactory estheticaleffects were maintained. The results demonst-rated BHAB had a good biocampatibility andcould be used as a bone graft substitute inmaxillofacial plastic repair. This kind of material could be carved and contoured ...